20

Why do modern mountain bike forks no longer use boots on fork stanchions? Older mountain bikes used to have them on the forks, and lefty and headshocks still do. Why have these fallen out of fashion and would putting aftermarket fork boots on your stanchions be productive or not?

Improve this question

2 Answers 2

Reset to default
11

As technology goes, seal and wiper advance to the point that boots on fork stanchions becomes obsolete, for both economical and practical reasons.

The seal has advanced to the point that air suspension fork was possible and economical, leaving alone keeping dirt and grimes off the suspension.

So the answer is Technical obsolescence

Edit: And as @DeletedUser points out in a comment, the boots could cause more harm than good by holding moisture and dirt against the forks in places where they aren’t visible to the user.

Improve this answer
2
  • 2
    Is there research concluding that there is no effect in adding external protection? The reason might be connected to visual appeal too. I have hard time believing that any seal, not matter how good, will not be impacted by mud and ground coming into contact with it.
    – vex
    Sep 18, 2017 at 13:05
  • 3
    Yes. In some instances the boot was actually worse. Once they cracked or stretched, they had a tendency to hold muck and moisture against the fork, accelerating wear.
    – Deleted User
    Sep 18, 2017 at 14:03
1

Personally I think the trend to no boots is a bad one. If you look at auto shocks, which have been around much longer than mountain bike shocks, almost all of them have boots. I just bought a new car and the shock has boots. Modern mountain bike shocks without boots need to be serviced much more often due to dirt ruining the seals faster in my experience. So, I believe the removal of the boot guarantees the manufacturer and bike shop more revenue to service the shocks more often.

Improve this answer
2
  • 2
    Hi, welcome to bicycles. Do you have any evidence, other than a feeling, that it is intended to increase the service requirements? Another answer here suggests that the boot was trapping dirt and moisture, and modern forks are better without it, so you should provide better support than just your opinion.
    – DavidW
    May 12, 2020 at 3:30
  • 1
    The automotive comparison is a good one - my car's shocks don't have boots, so its not an absolute there either.
    – Criggie ♦
    May 12, 2020 at 9:24

Your Answer

By clicking “Post Your Answer”, you agree to our terms of service and acknowledge that you have read and understand our privacy policy and code of conduct.

Not the answer you're looking for? Browse other questions tagged or ask your own question.